Advanced search

Sciences in Cold and Arid Regions ›› 2020, Vol. 12 ›› Issue (2): 59-70.doi: 10.3724/SP.J.1226.2020.00059.

    Next Articles

Thermal influence of ponding and buried warm-oil pipelines on permafrost: a case study of the China-Russia Crude Oil Pipeline

YanHu Mu1,MingTang Chai1(),GuoYu Li1(),Wei Ma1,Fei Wang1,2,YaPeng Cao1,2   

  1. 1.State Key Laboratory of Frozen Soil Engineering, Northwest Institute of Eco-Environment and Resources, Chinese Academy of Sciences, Lanzhou, Gansu 730000, China
    2.University of Chinese Academy of Sciences, Beijing 100049, China
  • Received:2019-10-01 Accepted:2019-12-26 Online:2020-04-30 Published:2020-04-27
  • Contact: MingTang Chai,GuoYu Li E-mail:cmt620422@163.com;guoyuli@lzb.ac.cn

RichHTML

38

PDF (PC)

335

Abstract:

Buried pipelines are widely used for transporting oil in remote cold regions. However, the warm oil can induce considerable thermal influence on the surrounding frozen soils and result in severe maintenance problems. This paper presents a case study of the thermal influence of ponding and buried warm-oil pipelines on permafrost along the China-Russia Crude Oil Pipeline (CRCOP) in Northeast China. Since its operation in 2011, the operation of the warm-oil pipelines has led to rapid warming and thawing of the surrounding permafrost and development of sizable ponding along the pipeline route, which, in return, exacerbates the permafrost degradation. A field study was conducted along a 400-km long segment of the CRCOP in permafrost regions of Northeast China to collect the location and size information of ponding. A two-dimensional heat transfer model coupled with phase change was established to analyze the thermal influence of ponding and the operation of warm-oil pipelines on the surrounding permafrost. In-situ measured ground temperatures from a monitoring site were obtained to validate the numerical model. The simulation results show that ponding accelerates the development of the thaw bulb around the pipeline. The maximum thaw depth below the pipeline increases from 4 m for the case without ponding to 9 m for the case with ponding after 50 years of operation, and ponding directly above the pipe induces the maximum thaw depth. Engineering measures should be adopted to control the size or even eliminate surface water-rich ponding for the long-term performance of buried warm-oil pipelines.

Key words: ponding, heat transfer modeling, oil pipeline, permafrost, thaw depth

Figure 1

Location of the China-Russia Crude Oil Pipeline and Permafrost Distribution in China"

Figure 2

Four types of ponding based on its location relative to the pipelines: (a) between the two lines, (b) outside of the second line, (c) on both sides of the second line, and (d) on top of the second line"

Figure 3

Distribution of ponding occurrences based on the position (a) and length (b)"

Figure 4

Layout of boreholes (T1 and T2) and thermistor cablesat the monitoring site and assumed ponding"

Figure 5

Schematic diagram of four physical model scenarios: (a) outside the second line, (b) between the two lines, (c) on both sides of the second line, and (d) on top of the second line"

Figure 6

The measured oil temperature and the fitting result"

Table 1

Thermo-physical parameters used in thermal modelling"

Itemρ (kg/m3)W0Cf (J/(kg?K))Cu (J/(kg?K))λf (J/(m?h?K))λu (J/(m?h?K))
Water1,000-4,1182,1177,9201,944
Black peat45050%8901,0306,3002,600
Silty clay1,50035%1,2751,7306,0223,932
Gravel1,80015%9821,2736,5525,760
Weathered granite1,80015%9821,2736,5525,760
Insulation300%1,2501,250126126

Figure 7

Comparison between the measured data and model results for boreholes T1 and T2"

Figure 8

Evolution of permafrost temperature in borehole T1 without (a) and with (b) ponding"

Figure 9

Evolution of permafrost temperature in borehole T2 without (a) and with (b) ponding"

Figure 10

Evolution of the maximum thaw depth around the pipelines without ponding"

Figure 11

Evolution of the maximum thaw depth around the pipelines with ponding outside the second line"

Figure 12

Evolution of the maximum thaw depth around the pipelines with ponding between the two pipelines"

Figure 13

Evolution of the maximum thaw depth around the pipelines with ponding on both sides of the second line"

Figure 14

Evolution of the maximum thaw depth around the pipelines with ponding on top of the second line"

Figure 15

Variation of the permafrost thaw depth below the second line with time"

Abdalla BA, Mei H, McKinnon C, et al., 2016. Numerical Evaluation of Permafrost Thawing in Arctic Pipelines and Mitigation Strategies. Arctic Technology Conference. Offshore Technology Conference.
An WD, Wu ZW, Ma W, et al., 1990. Interaction among Temperature, Moisture and Stress Fields in Frozen Soil. Lanzhou: Lanzhou University Press. (in Chinese)
Burgess MM, Harry DG, 1990. Norman wells pipeline permafrost and terrain monitoring: Geothermal and geomorphic observations, 1984-1987. Canadian Geotechnical Journal, 27(2): 233-244. DOI: 10.1139/t90-027.
doi: 10.1139/t90-027
Brown J, Hinkel KM, Nelson FE, 2000. The Circumpolar Active Layer Monitoring (CALM) Program: Research design and initial results. Polar Geography, 24(3): 165-253. DOI: 10.1080/10889370009377698.
doi: 10.1080/10889370009377698
De Grandpré I, Fortier D, Stephani E, 2012. Degradation of permafrost beneath a road embankment enhanced by heat advected in groundwater. Canadian Journal of Earth Sciences, 49(8): 953-962. DOI: 10.1139/E2012-018.
doi: 10.1139/E2012-018
Dumais S, Konrad JM, 2019. Large-strain nonlinear thaw consolidation analysis of the Inuvik warm-oil experimental pipeline buried in permafrost. Journal of Cold Regions Engineering, 33(1): 04018014. DOI: 10.1061/(ASCE)CR. 1943-5495.0000179.
doi: 10.1061/
Erickson TR, Stefan HG, 2000. Linear air/water temperature correlations for streams during open water periods. Journal of Hydrologic Engineering, 5(3): 317-321. DOI: 10.1061/(ASCE)1084-0699(2000)5:3(317).
doi: 10.1061/
Fan SZ, Li GY, Mu YH, et al., 2017. Study on thermal hazards assessment at a typical site along the Mohe-Daqing section of China-Russia crude oil pipeline. Journal of Disaster Prevention and Mitigation Engineering, 37(3): 456-461.
He RX, Jin HJ, 2010. Permafrost and cold-region environmental problems of the oil product pipeline from Golmud to Lhasa on the Qinghai-Tibet Plateau and their mitigation. Cold Regions Science and Technology, 64(3): 279-288. DOI: 10.1016/j.coldregions.2010.01.003.
doi: 10.1016/j.coldregions.2010.01.003
Hu XY, Sheng Y, Peng EX, 2018. Effect of Thermokarst Lake on Foundation under Embankment in Permafrost Regions. Proceedings of China-Europe Conference on Geotechnical Engineering. Springer, Cham. 1364-1367. DOI: 10.1007/978-3-319-97115-5_101.
doi: 10.1007/978-3-319-97115-5_101
Jin HJ, Hao JQ, Chang XL, et al., 2010. Zonation and assessment of frozen-ground conditions for engineering geology along the China-Russia crude oil pipeline route from Mo'he to Daqing, Northeastern China. Cold Regions Science and Technology, 64(3): 213-225. DOI: 10.1016/j.coldregions.2009.12.003.
doi: 10.1016/j.coldregions.2009.12.003
Jin HJ, Sun GY, Yu SP, et al., 2008. Symbiosis of marshes and permafrost in Da and Xiao Hinggan Mountains in northeastern China. Chinese Geographical Science, 18(1): 62-69. DOI: 10.1007/s11769-008-0062-0.
doi: 10.1007/s11769-008-0062-0
Lai YM, Wang QS, Niu FJ, et al., 2004. Three-dimensional nonlinear analysis for temperature characteristic of ventilated embankment in permafrost regions. Cold Regions Science and Technology, 38(2): 165-184. DOI: 10.1016/j.coldregions.2003.10.006.
doi: 10.1016/j.coldregions.2003.10.006
Li GY, Sheng Y, Jin HJ, et al., 2010. Forecasting the oil temperatures along the proposed China-Russia Crude Oil Pipeline using quasi 3-D transient heat conduction model. Cold Regions Science and Technology, 64(3): 235-242. DOI: 10. 1016/j.coldregions.2009.08.003.
doi: 10. 1016/j.coldregions.2009.08.003
Li GY, Yu QH, Ma W, et al., 2016. Freeze-thaw properties and long-term thermal stability of the unprotected tower foundation soils in permafrost regions along the Qinghai-Tibet Power Transmission Line. Cold Regions Science and Technology, 121: 258-274. DOI: 10.1016/j.coldregions.2015. 05.004.
doi: 10.1016/j.coldregions.2015. 05.004
Li P, Zhang X, Lu X, 2019. Three-dimensional Eulerian modeling of gas-liquid-solid flow with gas hydrate dissociation in a vertical pipe. Chemical Engineering Science, 196: 145-165. DOI: 10.1016/j.ces.2018.10.053.
doi: 10.1016/j.ces.2018.10.053
Mu YH, Ma W, Li GY, et al., 2018. Impacts of supra-permafrost water ponding and drainage on a railway embankment in continuous permafrost zone, the interior of the Qinghai-Tibet Plateau. Cold Regions Science and Technology, 154: 23-31. DOI: 10.1016/j.coldregions.2018.06.007.
doi: 10.1016/j.coldregions.2018.06.007
Nixon JF, Oswell JM, 2010. Analytical solutions for peak and residual uplift resistance of pipelines. Proc., 63rd Canadian Geotechnical Conf. and 6th Canadian Permafrost Conference. 570-578.
Oswell JM, 2011. Pipelines in permafrost: geotechnical issues and lessons. Canadian Geotechnical Journal, 48(9): 1412-1431. DOI: 10.1139/T11-045.
doi: 10.1139/T11-045
Périer L, Doré G, Burn CR, 2015. Influence of water temperature and flow on thermal regime around culverts built on permafrost. In: Proceedings of the 68th Canadian Geotechnical Conference and the 7th Canadian Permafrost Conference, 20-23 September 2015. Canadian Geotechnical Society, Québec City, Québec Canada digital release. .
Seligman BJ, 2000. Long-term variability of pipeline-permafrost interactions in north-west Siberia. Permafrost and Periglacial Processes, 11: 5-22. DOI: 10.1002/(SICI)1099-1530(200001/03)11.
doi: 10.1002/
Selroos JO, Cheng H, Vidstrand P, et al., 2019. Permafrost thaw with thermokarst wetland-lake and societal-health risks: dependence on local soil conditions under large-scale warming. Water, 11(3): 574. DOI: 10.3390/w11030574.
doi: 10.3390/w11030574
Smith SL, Burgess MM, Taylor AE, 2003. High arctic permafrost observatory at Alert, Nunavut-analysis of a 23 year data set. Proceedings of the 8th International Conference on Permafrost, 21-25 July 2003, Zurich, Switzerland. AA Balkema, Lisse, the Netherlands, pp. 1073-1078.
Wang F, Li GY, Ma W, et al., 2018a. Permafrost thawing along the China-Russia Crude Oil Pipeline and countermeasures: A case study in Jiagedaqi, Northeast China. Cold Regions Science and Technology, 155: 308-313. DOI: 10.1016/j.coldregions.2018.08.018.
doi: 10.1016/j.coldregions.2018.08.018
Wang F, Li GY, Ma W, et al., 2018b. Influence of Warm Oil Pipeline on underlying Permafrost and Cooling Effect of Thermosyphon based on Field Observations. Proceedings of China-Europe Conference on Geotechnical Engineering. Springer, Cham, pp. 1424-1428.
Wang YP, Jin HJ, Li GY, 2016. Investigation of the freeze-thaw states of foundation soils in permafrost areas along the China-Russia Crude Oil Pipeline (CRCOP) route using ground-penetrating radar (GPR). Cold Regions Science and Technology, 126: 10-21. DOI: 10.1016/j.coldregions.2016. 02.013.
doi: 10.1016/j.coldregions.2016. 02.013
Wen Z, Zhelezniak M, Wang DY, et al., 2018. Thermal interaction between a thermokarst lake and a nearby embankment in permafrost regions. Cold Regions Science and Technology, 155: 214-224. DOI: 10.1016/j.coldregions.2018.08.010.
doi: 10.1016/j.coldregions.2018.08.010
Wu QB, Zhang TJ, 2010. Changes in active layer thickness over the Qinghai-Tibetan Plateau from 1995 to 2007. Journal of Geophysical Research: Atmospheres, 115: D09107. DOI: 10.1029/2009JD012974.
doi: 10.1029/2009JD012974
Xu XZ, Wang JC, Zhang LX, 2001. Physics of Frozen Soils. Science Press, Beijing, China. (in Chinese)
Yoshikawa K, Hinzman LD, 2003. Shrinking thermokarst ponds and groundwater dynamics in discontinuous permafrost near Council, Alaska. Permafrost and Periglacial Processes, 14(2): 151-160. DOI: 10.1002/ppp.451.
doi: 10.1002/ppp.451
You YH, Wang JC, Wu QB, et al., 2017. Causes of pile foundation failure in permafrost regions: The case study of a dry bridge of the Qinghai-Tibet Railway. Engineering Geology, 230: 95-103. DOI: 10.1016/j.enggeo.2017.10.004.
doi: 10.1016/j.enggeo.2017.10.004
Zhang JM, Qu GZ, Jin HJ, 2010. Estimates on thermal effects of the China-Russia crude oil pipeline in permafrost regions. Cold Regions Science and Technology, 64(3): 243-247. DOI: 10.1016/j.coldregions.2009.10.001.
doi: 10.1016/j.coldregions.2009.10.001
[1] ShanShan Chen,ShuYing Zang,Li Sun. Characteristics of permafrost degradation in Northeast China and its ecological effects: A review [J]. Sciences in Cold and Arid Regions, 2020, 12(1): 1-11.
[2] MingTang Chai,YanHu Mu,GuoYu Li,Wei Ma,Fei Wang. Relationship between ponding and topographic factors along the China-Russia Crude Oil Pipeline in permafrost regions [J]. Sciences in Cold and Arid Regions, 2019, 11(6): 419-427.
[3] Wei Cao,Yu Sheng,Ji Chen,JiChun Wu. Applying the AHP-FUZZY method to evaluate the measure effect of rubble roadbed engineering in permafrost regions of Qinghai-Tibet Plateau: a case study of Chaidaer-Muli Railway [J]. Sciences in Cold and Arid Regions, 2018, 10(6): 447-457.
[4] ZhenMing Wu, Lin Zhao, Lin Liu, Rui Zhu, ZeShen Gao, YongPing Qiao, LiMing Tian, HuaYun Zhou, MeiZhen Xie. Surface-deformation monitoring in the permafrost regions over the Tibetan Plateau, using Sentinel-1 data [J]. Sciences in Cold and Arid Regions, 2018, 10(2): 114-125.
[5] JianKun Liu, TengFei Wang, Zhi Wen. Research on pile performance and state-of-the-art practice in cold regions [J]. Sciences in Cold and Arid Regions, 2018, 10(1): 1-11.
[6] ChangWei Xie, William A. Gough. Comments on thaw-freeze algorithms for multilayered soil, using the Stefan equation [J]. Sciences in Cold and Arid Regions, 2017, 9(6): 525-533.
[7] Yan Lu, Xin Yi, WenBing Yu, WeiBo Liu. Numerical analysis on the thermal regimes of thermosyphon embankment in snowy permafrost area [J]. Sciences in Cold and Arid Regions, 2017, 9(6): 580-586.
[8] Rudolf V. Zhang. Utilizing natural cryogenic resources to improve the stability of natural-technical systems in the permafrost zone [J]. Sciences in Cold and Arid Regions, 2017, 9(4): 339-342.
[9] Feng Zhang, ZhaoHui(Joey) Yang, JiaHui Wang, HaiPeng Li, Benjamin Still. Shear properties of thawed natural permafrost by bender elements [J]. Sciences in Cold and Arid Regions, 2017, 9(4): 343-351.
[10] L. Gagarin, A. Melnikov, V. Ogonerov, I. Khristophorov, K. Bazhin. Phenomena caused by seismic and geocryological processes across linear infrastructure, South Yakutia, Russia [J]. Sciences in Cold and Arid Regions, 2017, 9(4): 352-362.
[11] Eduard Severskiy. Permafrost response to climate change in the Northern Tien Shan [J]. Sciences in Cold and Arid Regions, 2017, 9(4): 398-403.
[12] YuChi Liu, ZhiGang Song. Study on the adaptability of block-rock embankment in permafrost regions [J]. Sciences in Cold and Arid Regions, 2017, 9(4): 412-419.
[13] JiLiang Wang, ChenXi Zhang, XinLei Na. Analysis of bearing capacity of pile foundation in discontinued permafrost regions [J]. Sciences in Cold and Arid Regions, 2017, 9(4): 420-424.
[14] Alexey Piotrovich, Svetlana Zhdanova. Subgrade-reinforcement techniques for the dangerously deforming sections of railway lines in the north of the Russian Far East [J]. Sciences in Cold and Arid Regions, 2017, 9(3): 197-204.
[15] Aleksey Lanis, Denis Razuvaev. Systematization of features and requirements for geological survey of railroad subgrades functioning in cold regions [J]. Sciences in Cold and Arid Regions, 2017, 9(3): 205-212.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!